3 January 1996 Method, sensor, and system for temperature noncontact measurement under nonstationary reradiation conditions
Author Affiliations +
Proceedings Volume 2594, Self-Calibrated Intelligent Optical Sensors and Systems; (1996); doi: 10.1117/12.229238
Event: Photonics East '95, 1995, Philadelphia, PA, United States
Abstract
For non-contact measurement of temperature under strong reradiation with the objects having nearly equal temperature levels conventional methods are not accurate. Method in which measurement of two heat fluxes, one of that is descending on surface of object and second is ascending from object, have been developed. Temperature of the object surface is computed in real time by sequential approximation method using the calibration curves that are received by preliminary experimental investigation of corresponding materials. Method was tested for wide range temperature measurement. Comparison of this method with thermocouple measurements shows a very good accuracy even for low temperature range. Original sensors for high temperature and high heat flux application were developed. One of the advantages of sensors is their capability for accurate measurement of temperature under strong convection influence. The system includes also microprocessor and special software for calibration and temperature measurement. Main application of the system is ovens and furnaces for metallurgy, environmental testing chambers and object temperature monitoring.
© (1996) COPYRIGHT Society of Photo-Optical Instrumentation Engineers (SPIE). Downloading of the abstract is permitted for personal use only.
Pavel V. Miodushevsky, "Method, sensor, and system for temperature noncontact measurement under nonstationary reradiation conditions", Proc. SPIE 2594, Self-Calibrated Intelligent Optical Sensors and Systems, (3 January 1996); doi: 10.1117/12.229238; http://dx.doi.org/10.1117/12.229238
PROCEEDINGS
8 PAGES


SHARE
KEYWORDS
Sensors

Temperature metrology

Heat flux

Copper

Transducers

Calibration

Dielectrics

RELATED CONTENT

Optical imaging based on compressive sensing
Proceedings of SPIE (August 18 2011)
CCD mosaics--past, present, and future: a review
Proceedings of SPIE (July 09 1998)
Modular FDDI bridge and concentrator
Proceedings of SPIE (February 01 1991)

Back to Top