Translator Disclaimer
24 April 2003 Shell-type micromechanical oscillator
Author Affiliations +
Proceedings Volume 5116, Smart Sensors, Actuators, and MEMS; (2003) https://doi.org/10.1117/12.499107
Event: Microtechnologies for the New Millennium 2003, 2003, Maspalomas, Gran Canaria, Canary Islands, Spain
Abstract
Shell-type micromechanical resonators operating in radio frequency range were fabricated utilizing mechanical stress that is built into polysilicon thin films. Significant increase of the resonant frequency (in comparison with flat, plate-type resonators of the same size) and the rich variety of vibrating modes demonstrate great potential for "2.5-Dimensional" MEMS structures. A finite curvature of the shell also provides a mechanism for driving resonators by coupling in plane stress with out of plane deflection. By modulating the intensity of a low power laser beam (P~10μWatts) focused on the resonator we introduced a time-variable, in-plane, thermomechanical stress. This stress modulation resulted in experimentally observed, large amplitude, out-of-plane, vibrations for a dome-type resonator. A double laser beam experimental setup was constructed where mechanical motion of a shell-type resonator was actuated by a modulated, sharply focused Ar+ ion (blue) laser beam and detected by a red HeNe laser using an interferometric setup. A positive feedback loop was implemented by amplifying the red laser signal (related to the oscillator deflection) and applying it to modulate the blue (driving) laser beam. Stable self-sustained vibrations were observed providing that the feedback gain was high enough. Employing a frequency selective amplifier in the feedback loop allowed excitation of different modes of vibrations. Fine frequency tuning was realized by adjusting the CW component of either lasers' intensity or a phase shift in the feedback loop. Frequency stability better than 1 ppm (10-6) at 9 MHz was demonstrated for self-sustained vibrations for certain modes of the dome-shaped oscillators.
© (2003) COPYRIGHT Society of Photo-Optical Instrumentation Engineers (SPIE). Downloading of the abstract is permitted for personal use only.
Maxim Zalalutdinov, Keith L. Aubin, Christopher Michael, Robert B. Reichenbach, Tuncay Alan, Alan T. Zehnder, Brian H. Houston, Jeevak M. Parpia, and Harold G. Craighead "Shell-type micromechanical oscillator", Proc. SPIE 5116, Smart Sensors, Actuators, and MEMS, (24 April 2003); https://doi.org/10.1117/12.499107
PROCEEDINGS
8 PAGES


SHARE
Advertisement
Advertisement
RELATED CONTENT

Noise-Cancelling Mixers For Optical Fibre Communications
Proceedings of SPIE (January 01 1987)
Silicon Microresonator Transducers
Proceedings of SPIE (February 23 1989)
Resistively actuated micromechanical dome resonators
Proceedings of SPIE (January 24 2004)
Coupling of length scales in MEMS modeling the atomic...
Proceedings of SPIE (April 10 2000)

Back to Top