Translator Disclaimer
20 October 2009 Effect of precipitations on the damping capacity of Fe-13Cr-2.5Mo alloy
Author Affiliations +
Proceedings Volume 7493, Second International Conference on Smart Materials and Nanotechnology in Engineering; 74930T (2009) https://doi.org/10.1117/12.838392
Event: Second International Conference on Smart Materials and Nanotechnology in Engineering, 2009, Weihai, China
Abstract
The influence of precipitations on the damping capacity of Fe-13Cr-2.5Mo (mass %) based alloys has been investigated in this paper. The damping behaviors were examined by dynamic mechanical analyzer (DMA) at temperature t = 35 °C, vibrate frequency f = 1 Hz and strain amplitude ε of 10-6 and 10-3. Field-emission scanning electron microscope (FESEM) with X-ray energy dispersive spectrometer (EDS) was used to observe microstructure and determine the composition of precipitations. The results show that damping capacity of Fe-13Cr-2.5Mo based alloys is more strongly correlated with intragranular precipitation than with grain boundary (GB) precipitation. Fe-Cr-Mo alloy annealed at 1100 °C for 1 h followed by furnace cooling (FC) with relatively fewer intergranular precipitations, exhibits higher damping behavior. With the increase of annealing temperature, the amount of intragranular precipitations increases while damping capacity of Fe-Cr-Mo alloy decreases. Addition of 1.0% Ti obviously inhibits precipitation of GB precipitations, but promotes the intragranular precipitations in the alloy distinctly, so the damping capacity of Fe-Cr-Mo- 1Ti is slightly lower than that of Fe-Cr-Mo alloy. Addition of 1.0% Nb can significantly decrease damping capacity of Fe-Cr-Mo-1Nb at low strain amplitude. But at higher strain amplitude, damping capacity increases more rapidly and Fe- Cr-Mo-1Nb possesses the highest damping capacity. This result reveals that larger amount of precipitations in Fe-Cr-Mo based alloys can interact with dislocations and generate an amplitude-dependent dislocation damping Q-1dis at high strain amplitude.
© (2009) COPYRIGHT Society of Photo-Optical Instrumentation Engineers (SPIE). Downloading of the abstract is permitted for personal use only.
Xiaofeng Hu, Xiuyan Li, Bo Zhang, Lijian Rong, and Yiyi Li "Effect of precipitations on the damping capacity of Fe-13Cr-2.5Mo alloy", Proc. SPIE 7493, Second International Conference on Smart Materials and Nanotechnology in Engineering, 74930T (20 October 2009); https://doi.org/10.1117/12.838392
PROCEEDINGS
8 PAGES


SHARE
Advertisement
Advertisement
RELATED CONTENT


Back to Top